coal-fired fuel industrial steam boiler
All along, Zhangjiakou City, Hebei Province, took the central environmental protection supervision "look back" as the main problem of feedback opportunities to enhance the ecological environmental protection, pollution prevention and fight tough fight, active rectification, hard to rectify, resolute reform, promote the environmental reform task completed on schedule. We understand that in 2018, Zhangjiakou City Daly to promote projects cut coal, the accelerated clean alternative to coal consumption year on year in 2017 to reduce 1.04 million tons.
For unfinished "2017, the province's energy cut carbon coal down the main points of" cut annual coal requirements of mission objectives problem, Zhangjiakou City, supervisors coal companies cut coal, high quality coal, strengthen energy-saving technological transformation, to fully grasp the total coal consumption control and reduction of bulk coal.
The strengthening of key coal enterprises cut coal, to promote energy-saving technological transformation projects, several key coal enterprises to continuously improve energy standards. And vigorously promote the project minus coal, coal production in 2018 to defuse 8.6 million tons, out of coal-fired boilers 1663 units. Accelerate clean coal alternative, clean winter heating selected pilot cities in northern, rural complete "electricity instead of coal", "substitution of gas for coal" 6971. And vigorously develop renewable energy sources, as of 2018 the city's renewable energy installed capacity of 13,454,800 kilowatts, accounting for 74.2% of all electricity installed capacity, the highest in the country.
Dzl Series Steam Boiler is our company's flagship product. Our company has more than 70 years of accumulation of boiler technology, and we have a good understanding of the international market, and we have often reached cooperation with customers in Malaysia, Thailand, Bangladesh, Vietnam, Indonesia, and other regions, basically all Customers who know our company's Dzl Series Steam Boilers will always choose our products because our Dzl Series Steam Boilers are more energy-efficient, safer and more economical. This product is mainly divided into two major series, DZL Packaged Biomass Steam Boiler and DZL Series Coal Fired Chain Grate Boiler.
The transformation of low nitrogen boiler should be noted that what matters for retrofitting low nitrogen boiler should be noted that what? Of nitrogen oxide emissions is large, complex sources, environmental problems caused by acid deposition, fine particles, ozone, nitrogen oxides and analysis of contamination status must be further strengthened. If you do not take further measures to reduce emissions, with the United States and the United States to speed up economic development, population growth and urbanization, nitrogen oxide emissions will continue to grow in China in the future. Based on current trends, by 2030, emissions will reach 35.4x106 tonnes, will inevitably cause serious environmental impacts. Therefore, we must effectively enhance the emission control of nitrogen oxides. From this we can see that low nitrogen boiler is imperative! A check device to check for low NOX combustion gas before commissioning is in place, the gas pipeline flow is clean, whether the valve is open. There is a burner pipe leaks, reasonable pipeline installation. Discharging vent pipe valve from the foregoing, to ensure that no mixing of the air duct, and the exhaust pipe should be connected to the outdoor. Second, stable combustion and combustion of homeostasis Remember, combustion adjustment is the basis for all of the low nitrogen burner adjustment, as long as guaranteed under any changes in operating conditions of combustion stability and combustion of dynamic equilibrium, to burn steam temperature influence is even greater. Since the steam temperature is a sign flue gas heat value balance between the steam and heat absorption, this can be maintained as long as the dynamic balance, steam temperature can be kept stable. Third, the level of flame boiler boiler central flame center is also an important factor in high impact low-temperature steam. In the high temperature steam operation, the amount of coal combustor exhaust can be reduced, the amount of the lower stage burner of coal may be increased, and vice versa. Running low nitrogen burners, it should also be noted effect of different combinations of temperature steam mill. Steam at a low temperature exhaust composition regulating a large margin, the combination of the high temperature exhaust temperature adjusting stage so small margin overheat. It should be strengthened and soot blowing air distribution according to the situation.
Several factors underlie the vertical coal-fired fuel industrial steam boiler efficiency China has been working to catch on coal to natural gas, vertical steam boiler with greatly reduced contamination of dust, smoke and other effects of a nitric oxide gas has also been healthy curb. Efficiency is an important indicator of a measure of vertical steam boiler, a good number of factors under the topic to discuss the direct impact of vertical steam boiler efficiency began. After analysis of stakeholders, heat loss from vertical steam boiler contains two pieces: the proportion of full combustion air with flue gas emissions unreasonable heat loss. Heat loss can be reduced smoke emission can be installed at the end of the vertical steam boiler stack waste heat reuse install, or more leading system with condensing boiler. Combustion air ratio sufficient unreasonable faults into: general vertical ejector-type steam boiler burner selection, resulting in a motor fuel ratio can not be adjusted. Most of the selected vertical steam boiler is mechanically strong emission combustion engine, air-fuel ratio resulting irrational factors are the following: air-fuel ratio can be divided into two reasonable chance comprising: when the air in excess, the excess will have full cold It is heated, resulting in increased operating costs vertical steam boiler, steam boiler efficiency vertical drop; when the air is not enough, will produce insufficient burning phenomenon, caused by vertical steam boiler efficiency.