1000kg water tube oil steam boiler
Some knowledge boiler Introduction: boiler is an energy conversion device, the energy input to the boiler chemical energy, electrical energy, a boiler with a steam output of the fuel in the constant heat, high temperature water or organic heat carrier. Today introduced are several little knowledge about the boiler. 1, a way to improve the efficiency of the boiler A which:? ⑴ low heat losses: prevent heating surface fouling and coking, the rational use of the burner, controls the blower inlet air temperature, water temperature of attention to the impact, into the furnace to avoid excessive wind note impact milling system operation; ⑵ mechanical incomplete combustion to reduce heat loss: rationally adjust the fineness of pulverized coal, the excess air ratio control of appropriate, attention combustion adjustment; ⑶ quality assurance fired boilers; ⑷ reduce soda losses: guaranteed boiler quality water supply, installation and maintenance to improve the quality of the steam separator means, to maintain the operation of the boiler load, the water level, steam pressure and other parameters of stability, so that the boiler water separation apparatus operating under normal conditions; ⑸ index management adhere to the small boiler. ? What are the reasons boiler fire answer: ⑴ low boiler load, low temperature furnace, combustion temperature, combustion oil investment is not timely; ⑵ poor coal quality, low volatile matter, ash is too large; ⑶ air volume to adjust properly, once too high wind speed, wind powder imbalance, the excess air ratio is too large; ⑷ excessive negative pressure maintaining furnace; ⑸ bunker powder level is too low or fallen powder to the powder to make the powder unevenness; ⑸ large depression coke furnace, disturbances in the furnace is too large; ⑹ ash, coke playing time is too long, especially large caused by cold air leakage into the furnace temperature drops to a low load; ⑺ blast furnace tube, a large number of soft drinks into the furnace; ⑻ fire protection action; ⑼ device malfunction, such as sending, fan, tripping of mill, Auxiliary disappeared.
Since 2017, Yongji County, Jilin Province to respond positively to the State Council issued the "Air Pollution Prevention Action Plan" to carry out corresponding work strictly in accordance with national, provincial and municipal environmental requirements.
It is reported that out of Yongji County vigorously promote the renovation work of small coal-fired boilers, promulgated and implemented the "little out of Yongji County boiler work program" to develop "a furnace policy" policy, no longer approve new steam 10 t / h coal-fired boiler , while promoting the phase-out of small coal-fired boilers.
For small coal-fired boiler phase-out program has been effectively implemented, Yongji County Government has formulated "Yongji County eliminate small coal-fired boiler renovation award up approach", the county built area of active users to carry out remediation work out of coal-fired boilers by small standard for financial awards complement, after the introduction of premium policy, and in the mouth before the town government to convene Yongji economic Development Zone, the area held a small coal-fired boilers user related meetings, arrangements for specific phase-out management work, and to a great extent to promote the progress of small coal-fired boilers eliminated.
Since the initial carry out small coal-fired boiler renovation work in 2017 to the present day, Yongji county built-up areas out of a total of 59 small coal-fired boiler units, a total of 16 sets of 20 tons of steam / hour non-electric and coal-fired boilers intention has been completed to upgrade pollution control facilities renovation work.
Pressure test must be carried out before the oil and gas boiler operation: either 1000kg water tube steam boiler or hot water boiler in the boiler installation must be pressure test (ie, play water pressure). Because after long-distance transport, handling, installation, it is inevitable collisions and injuries through the boiler pressure test to discover defects promptly take appropriate measures in order to ensure the safe operation of the boiler. The following fuel gas-fired boiler to pressure test as an example:
Oil-fired boiler combustion control and automation and whether the fuel tank on the role of specific types of boiler, this article will be introduced below, for this kind of boiler oil-fired boiler, but for now, this kind of boiler is widely application, is a common and popular types of boilers, so based on these two points, it should be taken seriously and work to learn the product, good to have a good use of effects through proper use. Notes 1. What are oil-fired boilers? This oil-fired boiler A boiler, through which the oil is atomized fuel oil burners, and then mixed with air, in suspension a combustion apparatus for combustion in the furnace. Larger capacity fuel boilers, mostly use heavy, but the larger the viscosity of heavy oil must be preheated before combustion; if the capacity is small, is the use of light oil, no need for preheat. In addition, oil-fired boilers for industrial use, mostly fueled with the use of light diesel oil. 2. whether the oil-fired boiler combustion and control system can be automated? The issue from a professional point of view, the answer is you can, that is, oil-fired boiler burning automation and control systems can be used. In addition, this kind of boiler fuel needs to be injected into the boiler furnace combustion chamber and the use of fire, there is no need to use grates facilities. Fuel oil-fired boiler does not produce ash after combustion, therefore, do not need to slagging facilities. 3. Does the oil-fired boiler have different classification criteria? It corresponds to the specific types of what? This kind of boiler oil-fired boiler, which is a different classification criteria, and correspond to different species at different classification criteria. If the fuel according to the type can be divided into two heavy gas oil boilers and boiler, light oil and kerosene are those diesel, heavy oil refers to crude oil after extraction remaining heavy gasoline or diesel oil. If use according to points, can be divided into a fuel oil-fired boiler water boilers, hot water boiler fuel, heating fuel boiler, oil bath boilers and 1000kg water tube steam boiler fuel these. 4. whether the oil-fired boiler can be automatic oil burner? Why have their fuel tanks? On oil-fired boilers, can be automated using the oil burner, the ignition from the normal combustion, the air supply from the oil supply to the flame detector, and so can be automatic protection automatically, without manual operation. And this kind of boiler installed on the tank, one can play a role in filtering sediment, and second, to solve this problem come from oil-absorbing far away.