steam generator in sugar factory
To further promote the comprehensive management of coal-fired boilers, Jincheng City, Shanxi Province, according to "Jincheng Blue win the Battle of three-year action plan" requirements, plans to complete 109 units of 10-20 tons of steam "small coal-fired boilers" within this year the phase-out, at the same time, Jincheng will start working out of 35 tons of steam coal-fired boilers.
This year, Jincheng counties (cities, districts) the environmental sector will urge the relevant enterprises and institutions to eliminate the basis of 10 tons of steam and coal-fired boilers on in 2018 to accelerate the phase-out and 20 tons of steam coal-fired boilers. This year, the city to complete 109 units (10-20 tons of steam boilers) working out of a total of 589.5 tons of steam boilers; at the same time, Jincheng will also speed up the foundation and 20 tons of steam coal-fired boiler out, start 35 tons of steam phase out coal-fired boilers, in principle, within the city's new domain-wide 35 tons of steam coal-fired boilers.
In addition, Jincheng will accelerate the transformation of ultra-low emission. Before the end of September this year, the city will complete 52 units (65 tons of steam per hour and higher coal-fired boilers) coal-fired heating boilers ultra-low total of 4530 tons of steam boilers transformation, and the county (city) built-up area, biomass boilers emissions transformation. After transformation, under condition of the reference oxygen content of 6%, soot, sulfur dioxide, nitrogen oxides emission concentration of these boilers respectively not higher than 10 mg / m, 35 mg / m and 50 mg / m.
Transformation of low nitrogen in the combustion aspect, before the end of October, Jincheng station 610 will complete the transformation of low-nitrogen combustion Total 1940.15 tons of steam gas boiler, after completion of the transformation, the boiler NOx emission will not exceed 50 mg / m.
Waste heat recovery steam generator in sugar factorys utilizing shop assembled or modular field construction.
Waste heat recovery steam generator utilizing extended surface (finned tube), and non-extended tube (bare tube) designs.
Free supervisory inspection gas steam boiler with a small do? Recently, many customers called to ask small steam boiler there? The problem I think has been plagued by many users, and now I am going to say about you in the end there is no small steam boiler. There are inscriptions specified in the country last year not to produce 0.3 tons less gas steam boiler, because of the very high probability of small vertical steam boiler accidents, often because of lack of water caused by the boiler, to the production of small countries is strictly prohibited after conventional steam boiler, the company's R & D staff spent half a year of successful development of a no-supervisory inspection, small steam boiler for the inspection of small steam boiler, specifications from 0.1 tons to 0.5 tons of gas, oil, gas, this does not require quality and technical supervision boiler inspection and acceptance, and acceptance-free steam generator in sugar factory water volume is less than 30L, according to state regulations, "steam boiler safety technology supervision" within the exemption permits boiler use a range of countries, namely without going through the boiler use permit. Eliminating the need for a year dealing with government departments, more peace of mind. Boiler with full intelligent automatic control technology, as long as someone to fill the fuel inside the boiler on it, if the boiler water itself it will automatically go inside the boiler water, high degree of automation, pressure can reach 10 kilograms, gas for 3 minutes can the steam, fuel gas only three minutes to reach 4 pressure.
ZBG further stated, "This Advanced Bio CFB -- or ABC -- is the largest and most advanced biomass CFB steam generator in sugar factory ZBG has ever supplied. Our goal for this project was to provide GDF Suez with a reliable, biomass-flexible boiler that would allow the client to build a high-efficiency green power plant - and we have achieved that objective."