china gas hot water boiler
What is the main danger steam boiler? The main danger emergency steam boiler 1, surveillance, hazard control boiler steam boiler regular inspection tours, and monitor pressure, water level, temperature and combustion conditions to control the boiler operating conditions. And to take timely measures to ensure safety. 2, the processing operation of the steam boiler in special circumstances: (1) water shortage phenomenon: When the boiler water, the water level below the water table level limits not visible, low water level alarm emits an alarm, bell lights, low interlocking means so that the water level blower, fan, etc. closure operation; boiler exhaust gas temperature rise, a serious lack of water, lake taste top coke production, the door can be seen from the red-hot waterwall tubes, tube deformation or even explosion pipe, can be heard blasting sound, smoke and steam discharged from the door to see the fire door. Treatment: When judged as a serious water shortage, should an emergency shutdown, non-serious water shortage boiler water to the boiler. Immediately stopping the supply of fuel, the wind stops blowing weakened, the front portion of the coal grate furnace Pa, the maximum switch the grate, combustion slag hopper falls quickly, with irrigated off, after extinguishing the fire, stop the wind, open ash door, the door to promote accelerated cooling. Note: Do not feed water to the boiler, shall take measures to prompt blood pressure, prevent the accident, to refrain from watering methods to the furnace fire put out the fire. (2) boiler overpressure phenomenon: a sharp rise in steam pressure, exceeds the allowable working pressure gauge pointer over the "red line", the safety valve, the pressure is still elevated, issued overpressure alarm, steam temperature and steam flow rises cut back. Processing: weakened rapidly burning, manually open the vent valve or safety valve, to increase the water supply, sewage increase (normal water level at this time to keep the boiler), thus reducing the temperature of the boiler water a boiler drum pressure decrease. (3) boiler tube phenomenon: the waterwall tubes blasting significant audible pops or jet sound, until the furnace by the combustion pressure becomes the negative pressure combustion, flue gas and steam and has viewed from the fire door, the door does not close, etc. discharge, although the water supply amount is increased, but difficult to maintain the normal water level and the pressure reduced, the amount of water to abnormally greater than the amount of steam, the exhaust gas temperature decreases, the chimney white smoke, the furnace temperature is reduced, or even extinguished, water flow out of the bottom of the boiler. Treatment: furnace tube rupture is not serious and can maintain the water level when the accident not to expand, may reduce short-term load operation, serious burst pipe and the water level can not be maintained, must be an emergency shutdown. But the wind should not stop, should continue to Sheung Shui, lower wall temperature. Such as: lack of water wall overheating, while burst pipes, emergency shutdown should be prohibited to the boiler feed water, the withdrawal of the furnace over the fire as soon as possible, reducing the furnace temperature, reducing the degree of superheating boiler. (4) steam boilers will produce full of water, such as priming scene of the accident, should take timely and effective measures to eliminate given. (5) boiler operation, in the event when one of the following circumstances, should immediately shutdown :( a) boiler water level below the lowest water level gauge visible edge; (b) increasing water supply and other measures, but the water level continued to decline; (iii ) boiler water level exceeds the highest visible level, the drainage can not see the water level; (iv) to pump all the water system failure or malfunction, not bottled water to the boiler; (e) all of the water table or valve failure; (vi) is set in a stripping all space gauge failure; (vii) damage the boiler element and endanger the safety of operating personnel.
Gas boiler water treatment in the application of protective measures II: to prevent the boiler fire blasting has been included in the ministerial twenty counter-measures, including fire protection, including the FSSS has been promoting the use of many power plants, it highlighted a few points : 1. references to the fire blasting. Key anti-ministerial twenty measures of the five. Called boiler fire to prevent shooting accidents. The blast furnace is correct formulation, because electric boilers, oil-fired boiler and gas furnace boiler furnace explosion caused damage not only in the operation of the fire, the flare ignited focused overhaul of combustibles and purge the ignition is not the same explode resulting in damage to the furnace.
July 26, 2016, Beijing, China Everbright Paper Co., Ltd. and the company signed a "split 6 tons of steam condensing gas steam boiler contract" by the company responsible for the WNS6-1.25-YQ split condensing gas boiler steam to all production, installation and commissioning work. The product is the use of condensing technology, effective emission of harmful substances SOx, NOx, COx, is industrial boilers efficient and environmentally friendly solutions.
Advantages of you know that china hot water boiler fast boiler below Henan small taping everyone understand the advantages of a hot water boiler, burner equipped with imported brands, high intelligence level, automatic purge command in accordance with the control panel, automatic electronic ignition, automatic lit, air oil (gas) accounted for automatic adjustment, characteristic An Kuaiping stable, easy to ignite. And there are flameout protection device to ensure safety will operate. 2, hot water boilers board computer, all of the action is stored in a wonderful smart chip, a furnace key switch, automatic automatic, constant temperature operation, the customer can be provided startup, shutdown time, set after, no responsible person on duty, convenient, save effort. 3, the outer fire tube inserted spoiler natural resistance, ease exhaust rate, to enhance heat transfer, low smoke chamber to exclude dust temperature, reducing thermal damage, save fuel. 4, the font sizes that vary depending on temperature, and easy to grasp the management status of the heating furnace system, a temperature of from 10 deg.] C to 90 deg.] C can be easily set to the automatic heating furnace or heating system for the customer to produce basic necessities, bath with boiling water. 5, control of boiler water temperature controlled circulating pump according to the start-stop, boiler water exceeds the set hot water circulation pump starting when the temperature limit is less than the lower limit set temperature of hot water circulating pump terminates. 7, with the bare metal disposed over temperature maintenance (the furnace temperature is wide, burner work done automatically terminated and beeps again over temperature maintenance time (shell furnace temperature exceeds 105 deg.] C, the secondary circuit is automatically disconnected), anti-aircraft burn less water maintenance (when the boiler water is less than the low water, the furnace terminate work to do and outgoing beeps), furnace leakage protection (technical inspection to control electrical appliances go, after the break, will automatically disconnect the power of the original) .8, superheated steam oven according Zongtisheji, no pressure in the heating furnace, the security will be no risk of .9, double insulation use high centrifugal glass wool, steel tile known as black boxes, less thermal damage, anti beautiful rust.