electric high efficiency hot water boiler
Gas electric high efficiency hot water boilers should be reinstated after discontinuation of the operation of the gas boiler content is one of the more common applications of industrial production equipment, many are relied on to solve the water problem, in order to ensure long-term gas boiler can maintain a stable working state, proper maintenance of the boiler is essential to go. If the gas boiler in the past has been shut down for a long time, how to restore normal? The first is the gas boiler thoroughly cleaned, since when not used for a long time, then gas boiler from inside to outside is bound to accumulate a lot of dust, only to be cleaned before you can use a clean, clear to check out the actual condition of the boiler . After completion of the gas boiler cleaning, be sure to use hot air to dry them, but not both for heating the furnace walls and other accessories, this is likely to have adverse consequences. Right way is to place an electric heater in the bottom of the gas boiler, heated. When the gas boiler has just put into use when the need to place the desiccant should also pay attention to corrosion on the tray, the tray holding good drying effect, contribute to its normal use, so as to promote the effectiveness of its full potential gas boiler. In addition to long pauses use of gas-fired boilers to note the above operations, the daily maintenance is also very important and must be inspected once every few months we should note that the desiccant, promptly added; and each periodic inspection of boiler parts usage, have something to damage should be repaired or replaced. On this basis, gas boiler to regain the good performance to the previous, to provide the necessary heat for industrial production, its value can be fully tapped.
Function of different types of gas electric high efficiency hot water boiler is not the same for each fuel boilers are not the same, with some coal to burn, some with gas or fuel oil to burn, but also some combustion power, as well as the use of coal-water as a raw material slurry of combustion. Some gas boiler is also been called a gas furnace. This is generally used for boiler fuel, but fuel is also classified, some heavy, some light oil. If the raw materials are burning gas, then this can also be classified, some inside the city gas use, there is natural gas. Burning hot water boiler to heat water to a boil, whether kerosene or gas as raw material are possible. The use of gas to boil water in the boiler, use gas to heat water in the boiler, use gas to generate steam boiler works, etc. belong to this series of boiler gas boiler. Use hot water boilers to burn gas, it has a name, that is the use of gas to provide heating boiler, there is the use of the gas boiler can boil water and take a bath. This boiler can be inferred from the name on it out of the raw materials used are burning gas. In use among gas boiler and boiler fuel use and the use of electric power boiler combustion, they are more affordable economy. But the most inexpensive gas boiler or the use, of course, this is the choice of many people. Gas-fired boiler is very common in daily life, a lot of heating, bath facilities are of this boiler. The benefits of using gas to boil water can be more, not only a short time to boil water, and gas usage is not too much, so that more of the cost.
Distinction gas steam electric high efficiency hot water boiler and a conventional coal-fired boilers and gas steam boiler (1) in a conventional coal fired boiler should be prechamber through grinding equipment, coal should be produced for combustion injected into the furnace, the entire combustion process in furnace and in the form of a suspension. (2) as long as the gas steam boiler biomass fuels open, dried and crushed, the helical feeder to the air before it is blown into the top of the combustion grate vibration. After burning the soot removed from the baghouse gas steam boiler. 2, different air supply preheating. Gas-fired steam boiler burner underlying mode, two-pass configuration, the fuel combustion, the boiler operation is stable and take up less space, while the spoiler is inserted smoke tube, smoke slow speed, increase heat transfer, a high thermal efficiency, reducing user fees (1) coal-fired boiler air preheater flue at the bottom, below the economizer; using flue (2) temperature of the air supply end of the cigarette is heated, different from a conventional boiler, the feed gas steam boiler air preheated by the air preheater flue gas cooler and the two parts to feed water as a medium to absorb heat of the flue gas, conveying air into the furnace. Warm air supply system for a gas steam boiler is controlled by adjusting the supply air temperature of the heating water flow can be provided by adjusting the electric charge of the bypass track circulation water through the valve and the air preheater flue gas cooler bypass control. Water heat exchange section, cooling water heated through the air preheater and the cold air delivery fan; then, this part of the water continues to flue gas cooler, flue gas by exchanging heat with water in the flue gas cooler, water heating, cooling the flue gas. In the bypass, a bypass flue gas cooler and another bypass air preheater, both have their own electrical control bypass and isolation valves. When the flue gas cooler exit gas temperature is too low, the bypass isolation valve is opened, water does not pass through the flue gas cooler, flue gas heat exchanger is not performed to ensure the flue gas cooler outlet gas temperature is not too low smoke corrode gas cooler. In order to enter the flue gas cooler feedwater temperature is not too low, when the air preheater outlet water temperature is below a certain temperature, it opens the bypass, supply cool air can not be heated, the water temperature is too low to prevent the influence of the flue gas cooler work . But also to ensure the temperature of the flue gas through a gas steam boiler precipitator. 3. The coal-fired boiler flue gas fired boiler bag filter should be used for desulfurization libraries to ensure the emission of pollutants lower than the standard. Steam boiler is an energy conversion device, the energy input to the boiler fuel chemical energy, electrical energy, thermal energy and other forms of high temperature flue gas, and after converting the boiler, the steam output having a certain outside thermal energy, high-temperature hot water or an organic carrier. Gas hot water boiler with environmental protection, energy conservation, safety, salient features fully automatic operation, and ease of use. In addition, due to the operation of the economy, government policies to encourage, gas hot water boiler more and more people of all ages. However, biomass combustion flue gas are different. Biomass fuel of low sulfur and nitrogen content, only through the biomass filter before discharge into the atmosphere. However, the carbon content of fly ash produced by the combustion of biomass, coal-fired boiler boiler efficiency is better, but the carbon dioxide content in the greenhouse can be reduced. Under the same nitrogen content of the fuel, the nitrogen oxides emission concentration of boiler far below the emission standards for coal-fired boilers. The problem should be noted that operation of the gas boiler. From the operational perspective view of the gas boiler, the operation of the gas boiler should note the following: The actual fuel consumption of the boiler operation, the amount of oil to the adjustment screw feeder. Unburnt fuel in the furnace, induced draft fan and the blower can not be stopped. Sudden power outage in operation, must be promptly removed fuel furnace. Not add biomass fuel before the shutdown. When the furnace stopped, there is no need of the bank up a fire. When the fuel on the grate exhausted, drum induced draft fan may stop running. If you want to know more about boiler, gas steam boiler, you can log on to our website, we look forward to your call!
Our environmental management efforts continue to increase, located in Wuhai City of Inner Mongolia is also actively respond to national policies, by removing, shutting down non-compliance of the measures within the jurisdiction of coal-fired electric high efficiency hot water boilers, etc., to improve air quality within the city.
Recently, a reporter to follow the staff Haibo Bay Area environmental monitoring brigade, examined the case of shutting down coal-fired boilers in rural areas. Trinidad town in Wuhai unity Village, coal-fired boiler is the main source of heat in the village residents, schools, hospitals in the town and airport, but because they do not meet environmental requirements, the boiler has been officially shut down at the end of 2018. Haibo Bay Area Environmental Protection Agency environmental monitoring battalion to us to: "Removing the boiler is 20 tons of steam coal-fired boilers, each heating season about to burn more than 3,000 tons of coal in accordance with the municipal government requirements. within the deadline 20 tons of steam boilers to be all removed, replaced with clean energy. since November 2018, this block of sea area has access to a central heating all children. "
So far in 2013, Wuhai City in strict accordance with regulatory requirements grid, earnestly implement the responsibility of inspectors on-site supervision, and has eliminated 20 tons of steam coal-fired boilers for heating and tea bath furnace 791 units, of which 2018 out of 58 units. Meanwhile, municipal and district environmental protection departments at all levels to increase on-site law enforcement and ensure that the boiler is no longer out of the resurgence. Up to now, it has no built-up area of Wuhai City and 35 tons of steam coal-fired boilers to achieve a stable discharge standards.