horizontal coal fired travelling grate steam boiler
6 tph WNS condensing gas-fired fire tube boiler project for chemical industrySichuan New Torch Chemical Co., Ltd. is mainly engaged in the research and development of hydrogen isotope products, providing safe, stable and high-quality products such as heavy water, deuterium generation reagents and high-purity hydrogen sulfide to the national defense cause. The production process of these chemical products is inseparable from the steam heat source provided by the boiler, which is one of the main power equipment on its production line.In the face of increasingly serious environmental pollution problems, China has continuously promoted the "coal to gas" policy. New Torch Chemical actively responded to environmental protection policies and decided to introduce horizontal coal fired travelling grate steam boilers that use clean energy as fuel. After understanding the demand and actual working conditions of Sichuan New Torch, ZOZEN recommended WNS series condensing gas-fired steam boiler. This series of gas-fired boilers adopts the structure of single drum, vertical type and wet back, which is safe and reliable. The combustion chamber adopts a large-diameter corrugated furnace to ensure full combustion of the fuel. With the advanced low NOx burner, it is easy to achieve low emissions of NOx ≤ 30mg/m³. In addition, ZOZEN installed energy-saving equipment at the tail of the flue according to the actual working conditions, so that the boiler thermal efficiency is as high as 98% or more, which is 5% higher than the similar boiler system on the market. Besides, the packaged characteristic of the boiler greatly shorten the installation cycle and reduce the installation cost.
Steam boiler accident type and processing method, and use common sense safety boiler horizontal coal fired travelling grate steam boiler accident type and processing method, overpressure accident 1 boiler, boiler overpressure phenomenon of (1) a sharp rise in steam pressure, exceeds the allowable working pressure gauge pointer over " red line "safety valve after the pressure is still elevated. (2) the operation of the device is the interlock overpressure protection, should send overpressure alarm signal, stops the air blowing, the wind, coal. (3) steam temperature and steam flow rate reduction increases. 2, to treat boiler overpressure (1) weakened rapidly burning, manually open the valve or bleed valve. (2) increase the water supply, while the lower reinforcing blowdown drum (It should be noted at this time to maintain the normal water level of the boiler), in order to reduce the temperature of the boiler water, thereby reducing the pressure in the boiler drum. (3) as a safety valve malfunction or all of the pressure gauge damage, emergency shutdown, safety valves and pressure gauges are to be repaired after the boost operation. When endanger the safe operation of (4) Boiler excessive pressure, blood pressure should take measures, but too fast buck is strictly prohibited. (5) boiler overpressure eliminate serious, to the shutdown of the boiler internal and external inspection, to eliminate the overpressure caused by deformation, leakage and other safety accessories and maintenance unqualified. Second, an accident boiler water, boiler water shortage (1) below the minimum safe water level line, or can not see the water level, the water level gauge glass (plate) as a white. (2) as a full-color water level gauge vapor instruction color. Low water level alarm signal (3) water level alarm occurs. (4) low water interlocking means, the water level should be below a prescribed value blower, Fan, grate reduction motor stops running. (5) a sharp rise in the superheater steam temperature, higher than the outlet steam temperature. (6) boiler exhaust gas temperature rises. (7) the water flow is less than the steam flow, causing Should the water tube due to tube cracking or economizer, an opposite phenomenon occurs. (8) When a serious water shortage, can smell the burnt smell. (9) When a serious shortage, the door can be seen from the red-hot waterwall tubes. (10) a serious water shortage, the furnace tube may rupture, then can hear the explosions, smoke and steam from the door, watching spray the fire door. 2, boiler water treatment (1) through the "waters", sentenced to severe water shortages, emergency shutdown must be prohibited blind to the boiler feed water. (2) through the "waters" sentenced to a slight lack of water, it should reduce fuel blast, the wind, and slowly feed water. Third, full water boiler 1 accident phenomenon (1) above the maximum allowable water level line, or can not see the water level, the water level gauge glass (plate) dark color boiler filled with water. (2) all of the water phase as a color level gauge indication color. High-water alarm signal (3) water level alarm occurs. (4) decreased superheated steam temperature. (5) water flow is not normally greater than the steam flow. (6) water in a large number of sub-cylinder, severe trap operation. (7) with a large amount of water steam severe, increased salinity, water hammer occurs in the sound of the steam pipe, the steam connection flange outwardly dripping take place. 2, boiler full of water treatment rinse water table, determined to be minor or serious full of water full of water. Method: Close water table, the water pipe connected cock, then open drain cocks As can be seen from the decreased water level, indicating a slight full of water, the water supply is stopped, the drain valve open, put to the normal water level. Such as severe filled with water due to take emergency shutdown measures.
Before a cooperation with the parties, we heard from other companies where fast boiler brand, saying it was so fast square product quality, use a long time, and after-sales service is also very complete. After the collaboration found that it really is a well-deserved reputation. This three boilers put into use, not only reduces emissions, while meeting the needs of normal heating, fuel input has also been reduced, as we save a lot of operating costs. --customer feedback
Horizontal industrial boiler for sale in India
ZG horizontal industrial boiler range which can be exported to India: horizontal fire tube boiler, horizontal water tube boiler, horizontal coal fired boiler, gas fired boiler, oil fired boiler, biomass fired boiler and so on. These product are featured with stability, quality, durability and reliability because our product are manufactured with top quality raw materials. The design, construction and superintendence of a wide variety of steam boilers, hot water boilers, and power plant boiler.