Run chemical plant boiler problems that may arise is what chemical plant boiler operation possible problem is? There are two main chemical plant boiler evaporation: evaporation and rated maximum continuous evaporation. When the chemical plant boiler load is higher than the maximum continuous evaporation, it indicates the operating force or overload. The following problems may occur super-load operation: Main results are as follows: (1) due to increased fuel consumption, furnace volume heat load increases, the furnace temperature and furnace flue gas outlet temperature, resulting in the superheater and reheater the superheated steam temperature and wall temperature, and must therefore be strictly monitored and adjusted. Try not to let this time overheating. Coal furnace, furnace volume due to the increased thermal load, increasing the likelihood of slagging. (2) the flow rate of chemical evaporation apparatus system working fluid increases, the flow resistance is increased, it is not conducive to water circulation. Therefore, we should pay particular attention to the monitoring of the water cycle bad area. (3) the pressure differential between the drum and the superheater outlet flow increases as the working fluid and superheater flow resistance increases, so that the pressure of the steam drum and headers increases, the strength of these components must be considered . Space volume load (4) the steam drum, the load increases the evaporation surface, saturated with water vapor would increase, thus affecting the quality of steam. (5) chemical plant boiler safety valve Total displacement designed according to a maximum continuous evaporation. If the chemical plant boiler overload, once the sudden load shedding, the safety valve will not fully open, the steam pressure can not be reduced quickly. At this point, it is necessary to ensure the safety of the boiler by chemical vapor released into the air exhaust valve. (6) With the increase of the amount of air required for combustion and the amount of smoke produced, once sufficient air supply, the air volume is insufficient, the chemical conditions affecting the combustion boiler, increasing the likelihood of slagging; In addition, since the flue gas velocity the increase in fly ash increased the degree of wear of the heating surface. (7) during operation, the exhaust gas temperature rises, the exhaust gas heat loss; shorter residence time in the furnace the fuel, incomplete combustion heat loss of mechanical and chemical incomplete combustion to increase the heat loss, reduce the thermal efficiency of the chemical plant boilers. In summary, the excess chemical plant boiler operation have an adverse impact on the security and economic, should generally not excessive run. If the special emergency must also be strictly limited scope and excess power beyond the time required to force.

Recently biomass fired CFB boiler technology is spread increase quickly in Europe.CFB boiler technology can also can be called clean coal technology,which can make industrial boiler more efficiently and environment friendly.CFB boiler can burning biomass or coal as fuel to produce steam or hot water whatever you need.

Our environmental management efforts continue to increase, located in Wuhai City of Inner Mongolia is also actively respond to national policies, by removing, shutting down non-compliance of the measures within the jurisdiction of coal-fired boilers, etc., to improve air quality within the city.

Recently, a reporter to follow the staff Haibo Bay Area environmental monitoring brigade, examined the case of shutting down coal-fired boilers in rural areas. Trinidad town in Wuhai unity Village, coal-fired boiler is the main source of heat in the village residents, schools, hospitals in the town and airport, but because they do not meet environmental requirements, the boiler has been officially shut down at the end of 2018. Haibo Bay Area Environmental Protection Agency environmental monitoring battalion to us to: "Removing the boiler is 20 tons of steam coal-fired boilers, each heating season about to burn more than 3,000 tons of coal in accordance with the municipal government requirements. within the deadline 20 tons of steam boilers to be all removed, replaced with clean energy. since November 2018, this block of sea area has access to a central heating all children. "

So far in 2013, Wuhai City in strict accordance with regulatory requirements grid, earnestly implement the responsibility of inspectors on-site supervision, and has eliminated 20 tons of steam coal-fired boilers for heating and tea bath furnace 791 units, of which 2018 out of 58 units. Meanwhile, municipal and district environmental protection departments at all levels to increase on-site law enforcement and ensure that the boiler is no longer out of the resurgence. Up to now, it has no built-up area of ​​Wuhai City and 35 tons of steam coal-fired boilers to achieve a stable discharge standards.

There are many types biomass fuel can be used in Biomass fired durable safety high quality efficient coal hot water boiler, such as Bagasse, wood chips, coal, corn cobs, straw, coffee grounds, palm shell, saw dust, cocnut shells, rice husk, red gram stalk, paddy stalk, wheat stalk, cotton stalk, coffee husk, julie flora, soya stalk, mustard stalk, etc.